SiH4 ‐ WF 6 Gas‐Phase Nucleated Tungsten as an Adhesion Layer in Blanket Chemical Vapor Deposition for Ultralarge Scale Integration
Year: 1997
Type: article
Abstract: In this work, the thin tungsten film nucleated by an in situ gas‐phase reaction in the low pressure regime (100 mTorr) was investigated and used as an adhesion layer to replace TiN in a blanket chemical vapor deposition of tungsten (CVD‐W) process. The deposition rate, step coverage, and film resistivity were studied as a function of the process parameters. Deposition rates from 360 to over 3000 nm/min were observed and increased with increasing deposition pressure and temperature. Moreover, we found that the deposition rate fell to zero when the temperature was less than 150°C. Also, the gas‐phase reaction vanished when the flow ratio was smaller than 1.6. On the other hand, the step coverage decreased with increasing deposition rate. Finally, the tungsten film resistivity was 167 μΩ‐cm which was comparable to that of a sputtered TiN film (about 150 μΩ‐cm) and also exhibited good adhesion ability on oxide when the temperature was higher than 200°C. Overall, the results indicate that this in situ gas‐phase nucleated tungsten film is an attractive replacement for TiN film in the blanket CVD‐W technique because of reduced process complexity, excellent step coverage, and low resistivity.
DOI: 10.1149/1.1837519
Institution: National Yang Ming Chiao Tung University
Language: English
Field: Materials Science
Domain: Physical Sciences
Open Access status: bronze
OpenAlex ID: W2013259184